Wire tuck/Intermittent Electrical/Main relay
I will go through and add pictures for this, and it may take some more experianced electrical gurus.
1995 Honda Civic Cx Fresh wire tuck, nothing was cut other than grounds in the engine bay on the white 8 plug ground terminals. On the main relay, i get no power to the fuel pump to prime. the t stat housing ground is connected. relay unplugged i have continuity to the fuel relay ground. Green/Yellow no power to the pump Yellow/White 12v battery supply is there Yellow/Black (ecu power) 11.4v yellow/Green -.51v (black to ground) Black/yellow 11.4v (II) Blue/White Ignition Switch -.51v (I) and 8v(II) Ignition Switch White 12vconstant black white starter 12v start black yelow 12v run start white black 12v run yellow I and II |
Re: Wiretuck/Intermitten Electrical/Main relay
How were the grounds reconnected? Soldered and shrink wrapped?
|
Re: Wiretuck/Intermitten Electrical/Main relay
The grounds themselves were ran through thefender. Ends were cut off and attached to butt style ring connectors.
|
Re: Wiretuck/Intermitten Electrical/Main relay
Checked all grounds for contunuity to the frame. All xhecked good. Next going to check every power and ground to the ecu
|
Re: Wiretuck/Intermitten Electrical/Main relay
is it a fuel pump prime delay? if so, it could be capacitor 14 in your ecu, this is a common issue
http://www.hondata.com/tech_capacitor_obd1.html https://honda-tech.com/forums/engine-management-tuning-124/chipped-p28-not-priming-fuel-pump-1159611/ |
Re: Wiretuck/Intermitten Electrical/Main relay
Both relay anf ecu tested in my teg. Tested fine.
|
Re: Wiretuck/Intermitten Electrical/Main relay
Its issues like this that make me rethink attempting to do a tuck
|
Re: Wiretuck/Intermitten Electrical/Main relay
Originally Posted by xero_xero
(Post 48301869)
relay unplugged... Green/Yellow no power to the pump |
Re: Wiretuck/Intermitten Electrical/Main relay
Ok.
Looking for the service tech manual at the moment. Does anyone have any pdf that are not scans? |
Re: Wiretuck/Intermitten Electrical/Main relay
Originally Posted by xero_xero
(Post 48316845)
Looking for the service tech manual at the moment.
|
Re: Wire tuck/Intermittent Electrical/Main relay
just rechecked everything. have continuity to the ecu grounds and chassis.
i get 9.5v from the blu/whi on start only, not run. 0v to fuel pump chassis ground and fuel pump ground i checked the jumper harness that i made to do the wire tuck, and every terminal end matches. and the next step is to undo the engine hanress and plug it strait. ill post up pics in about 15. |
Re: Wire tuck/Intermittent Electrical/Main relay
neglected ground.
after hours of tearing apart everything, i checked voltage at the chassis and on the physical grounds. broken ground wire off of the curent car i am driving. on harness, nearly impossible to find. pulled 5 volts when 12 was there. |
All times are GMT -8. The time now is 10:41 PM. |
© 2024 MH Sub I, LLC dba Internet Brands